VOLKSWAGEN GOLF IV

since 1997 of release

Repair and car operation



Foltsvagen Golf 4
+ 1. Maintenance instruction
+ 2. Engine
+ 3. Cooling system
+ 4. Fuel system
+ 5. Exhaust system
+ 6. Ventilation and heating system
+ 7. Coupling
+ 8. Transmission
+ 9. Suspension brackets and power shafts
+ 10. Steering
+ 11. Wheels and tires
+ 12. Brake system
+ 13. Body
- 14. Electric equipment and electroschemes
   14.1. Filament lamps
   14.2. Electric chains
   + 14.3. Detection of not closed chain
   14.4. Safety locks
   + 14.5. Accumulator
   + 14.6. Generator
   + 14.7. Starter
   14.8. Replacement of bulbs of external lighting
   14.9. Removal and installation of an additional signal of braking
   14.10. Replacement of bulbs of internal lighting
   + 14.11. Devices of external lighting
   + 14.12. Adjustment of light of headlights
   14.13. Removal and installation of a combination of devices
   14.14. Removal and installation of switches of a steering column
   14.15. Removal and installation of switches
   14.16. Removal and radio receiver installation
   14.17. Removal and installation of high-frequency loudspeakers
   14.18. Removal and installation of low-frequency loudspeakers
   14.19. Recommendations about phone installation
   14.20. Aerial
   14.21. Check of a heater of back glass
   + 14.22. Explanations to electric circuits
   + 14.23. Schemes of electric equipment of the VW Golf car since September, 1997.






14.4. Safety locks

GENERAL INFORMATION

Arrangement of the block of safety locks on the left side of the dashboard

The arrangement of safety locks and the electric chains protected by safety locks, are given in a sticker (it is shown by an arrow), located from the inside on a cover of the block of safety locks.

Arrangement of safety locks on the block of safety locks


Fuses are placed in the block of safety locks located on the left side of the dashboard.

Always replace a safety lock with other safety lock of the same capacity. Each safety lock has an inscription about size of a protected current. Never replace a safety lock more than once, without having defined the reason of its peregoraniye.

Additional safety locks are available on the relay block, the additional block of the relay and electronics block. The block of the relay is located in car salon on the left side under the dashboard. The block of electronics is located on the left side about a partition of a motor compartment.

On models with diesel engines the safety lock of system of preliminary heating of the diesel engine is located on a relay arm in electronics block.

Consumer of a current
And
1
Warmed jets of washers of a windshield, heating of external mirrors
5
2
Turn indexes
10
3
Internal lighting
5
4
Illumination of registration plate
5
5
Heating of seats, climatic installation
7,5
6
Central blocking of locks
5
7
Backing lamp
10
8
Phone
5
9
ABS control unit
5
10
Electronic systems of the engine
10
11
The selector (at an automatic transmission)
5
12
Phone
7,5
13
Braking signals
10
14
Plafonds and lamps for reading, the central blocking of locks
10
15
Automatic transmission
10
16
Stekloomyvateli
10
17
The warmed cylinder emphasis of a back door
7,5
18
Driving beam right
10
19
Driving beam left
10
20
Passing beam right, proof-reader of an inclination of headlights
10
21
Passing beam left
10
22
Marker and lay lights right
5
23
Marker and lay lights left
5
24
Stekloomyvateli
20
25
Fan of system of ventilation, climatic installation
25
26
Heating of back glass
20
27
Cleaner of back glass
10
28
Fuel pump
15
29
Electronic systems of the engine
10
30
Elevating and movable panel of the hatch of a roof
20
31
Automatic transmission
10
32
Electronic systems of the engine
10
33
Cleaners of headlights
20
34
Electronic systems of the engine
10
35
"Plus" of long power supply of the trailer
30
36
antifog lamps
15
37
"S" conclusion
20
38
Plafond of a luggage compartment, central blocking of locks
10
39
Emergency alarm systems
15
40
Sound signal
20
41
Lighter
15
42
Radio receiver
15
43
Electronic systems of the engine
10
44
Heating of seats
15

Prevention

The safety lock designated on the block of safety locks at number 24, on electric circuits of the car is designated by number 224, that is on electric circuits to number of a safety lock figure 2 is ahead added.


Replacement

PERFORMANCE ORDER
1. For replacement of safety locks open a cover for what insert a screw-driver from the bottom party into a groove which is marked out by an arrow, and press a cover.
2. If the safety lock fused, means, the conductor connecting contacts of a safety lock, is broken off.
3. To remove a safety lock, use tweezers for safety lock extraction from the socket. Get a safety lock from tweezers. The wire in a safety lock is easily appreciable and will be broken off, if the safety lock fused.
4. Establish the new safety lock calculated on the same current. From a reverse side each safety lock has an inscription about size of a protected current. Besides, color of a safety lock also corresponds to size of a protected current (see below).
5. Establish into place a cover of the block of safety locks.
6. If the established safety lock fuses repeatedly, check the electric chain protected by a safety lock.
7. At all do not replace a safety lock with a wire crossing point as the electric chain of the car can be seriously damaged.
Prevention

Characteristics of fuses and electric chains can change from year to year.



Current
Color
5
The light brown
10
The red
15
The dark blue
20
The yellow
25
The white
30
The green

Box of safety locks in a motor compartment on the storage battery

Safety locks
And
Fan of system of the cooling, 1st step
30
ABS electric motor relay
30
ABS main relay
30
Metal safety locks:
Generator
150
Onboard network
110
Fan of system of cooling 2nd step
30
Electronic systems of the engine
50
Prestarting heating of the diesel engine
50

Protection machine guns

Electric drives of window regulators all together and the hatch are protected also by the machine gun of protection which in case of an overload is automatically switched off (for example, at a primerzaniye of glasses) and in some seconds again joins.